|
Exhaust System:
[x] Replace Y-pipe (rotted out drivers side).
[x] Replace Y-pipe hanger strap.
[x] Replace muffler eliminators with mufflers.
Windshield Washer:
[x] Replace washer pump.
Drivers side mirror:
[x] Rattles. Need to tighten the mirror motor mounts.
Cruise control servo boot:
[x] Replace rotted boot.
Broken vacuum/vent hose:
[x] Replace rotted hose.
Outer door seals:
[x] Replace both outer door seals (passenger side seal is old and cracked).
Interior lamps:
[x] Replace door map lights w/LEDs.
[x] Replace rear view mirror map lights w/LEDs.
[x] Replace Rear view mirror console flood light w/LED.
[x] Replace foot-well lights w/LEDs.
[x] Replace cargo bay lights w/LEDs.
[x] Replace center console lid light w/LED.
Exterior lamps:
[x] Replace engine bay lights w/LEDs.
[x] Replace spare tire courtesy lamp w/LED.
Door panels:
[x] Reattach upper trim.
[x] Reattach carpet at top edge.
License plates:
[x] Purchase black frames.
[x] Purchase stainless steel screws w/black plastic caps.
Windshield wiper blades:
[x] Replace 20" windshield wiper blades with 18" blades.
[x] Remove the wiper arm lift ramps.
[x] Flatten the drivers side wiper arm curvature to factory specification.
Rear view mirror:
[x] Mounting screw is loose. Flops around.
[ ] Ball joints are loose. (de-grease and rough-up?)
[x] Replace burned out console flood light.
U-Joints:
[ ] Check inner and outer U-Joints (pass side making noise?)
Valve covers:
[x] Replace.
Idle speed:
[ ] Set minimum idle speed.
Coolant overflow bottle cap:
[ ] Replace disintegrated cap gasket.
Targa Tops:
[x] Replace drooping headliner in solid top.
[ ] Reattach the rubber head protector pads.
Climate control:
[x] Repair blinking control panel display/lights.
Battery:
[x] Trim lift handle from over-sized battery (pushing gill panel outward).
Center High Mount Stop Light (CHMSL):
[x] Replace bulbs with LEDs.
Reverse Gear / Ignition Key interlock:
[ ] Repair the reverse gear to ignition key interlock.
(currently you can take car out of reverse without unlocking steering column.)
Rear hatch weather-strip:
[x] Replace rear hatch weatherstrip (seal has detached from the U-channel body attachment)
Reprogram ECM:
[ ] Lower radiator cooling fan ON temperature (replace thermostat also)
[x] Default the 4+3 Overdrive to OFF.
[x] Eliminate the MAF Burn-Off test (code 36)
[ ] Add subroutine to slow-flash the OD indicator when OD is armed but OFF.
[ ] Repurpose the 'upshift for economy' indicator to redline upshift indicator.
|